MATERIAL SAFETY DATA SHEET
POVIDONE IODINE |
| Trade name |
|
PVP - IODINE(POVIDONE IODINE) |
| Synonyms |
|
|
| CHEMICAL IDENTITY |
|
POLYVINYL PYRROLIDONE-IODINE COMPLEX |
| FORMULA USE |
N/A |
CHEMICAL INTERMEDIATE |
|
| PHYSICAL DATA |
| MEL TING POINT
20°C |
: |
N/A |
|
VAP PRESSURE |
: |
< 0.1 MBAR@ |
| BOILING POINT |
: |
N/A |
|
VAPOUR DENSITY (AIR=1) |
: |
N/A |
| DECOMP TEMP |
: |
>350 C (GEIGY - KUEHNER) |
|
VOLATILES (%WT) |
: |
N/A |
| APPEARANCE AND ODOUR |
: |
Brown free- flowing powder, characteristic odour |
|
|
|
|
|
| Hazardous ingredients |
| Ingredients |
%w/w |
Cas no. |
Expos. Limit |
Toxicity |
Polyvinylpyrrolidonerate
|
60-100 |
25655-41-8 |
Not established |
LD50 Oral- |
| Iodine complex (nvpi) |
|
|
|
5600 mg/kg |
| |
|
|
|
|
|
| Fire and explosion hazards |
| Flash point : > 100 c |
Method : DIN 51758 |
Auto-ignition temp : N/d |
Flammablelimits in air (% by volume) : N/A
|
Lower : N/A upper : N/A |
| Extinguishig . Media [x] Water [x] Water Fog [] C02 [] Foam [ ] Dry Chemical |
| Other : N/D |
|
Burning Rate : N/D |
| Fire fighting areas producers. |
: |
Water self-contained breathing apparatus in confined
Or procedures when exposed to combustion |
| Unusual fire and |
: |
may form explosive dust-air mixture |
| Hazardous combustion products |
: |
NOx, CO2.HCN.I |
|
| Health Data |
|
| Toxicity : Acute Oral |
LDS : C.5600 mg/kg |
Tested On RAT |
| Route Of Entry : [ X ] Eye |
[ X ] Skin [X] Ingestion |
[ X ] Inhalation |
| Effect Of Acute Exposure |
| Eye and skin contact will cause irritation. Ingestion will cause adverse health effects. Inhalation will cause irritation of the respiratory tract. |
| Effects Of Chronic Exposure : |
| There are no known chronic effects associated with this material. |
| Skin Irritation |
|
Non |
| Eye Irritation |
|
Irritating |
| Carcinogenicity |
|
None Known |
| Teratogenicity |
|
None Known |
| Mutagenicity |
|
None Known |
| Exposure Limits |
|
Non Established |
| Reproductive Effects |
|
None Known |
| Other Health Data |
|
N/D |
|
| Production Information |
| Ventilation : General Mechanical : Adequate : Local Exhaust : Required : Other : N/D |
| Respiratory Production :
Approved Dust Respirator If Dusting Occurs. |
| Gloves : Rubber Plastic : Eyes ProtectionChemical Goggles |
| Other Prqtective Measures : Impermeable apron and boots to Prevent skin contact |
| First Aid |
| Eyes : |
Flush Immediately With Water For Atleast 15 Minutes.
Consult & Physician Immediately. |
| Skin : |
Rinse With Flowing Water For Atleast 16 Minutes.
Consult A Physician Immediately. |
| Ingestion : |
Give Water Or Milk.
Do Not Induce Vomiting.
Consult A Physician Immediately. |
| Note : |
If victim is unconscious, never induce vomiting nor given liquids.
Place victim in a stable side position and keep warm |
| ...........................................................INHALATON : Remove to fresh air Assist if Necessary. Consult a physician. |
| Reactivity Data |
Stability : Stable [ x ] Conditions to avoid :
Unstable [ x ] Protect from humidty (product is hygroscopic) |
| Incompatibility : Excessive heat, reducers. |
| Hazardous Decomposition Products : N/D |
Hazardous Polymerization : Conditions to avoid :
May Occur [ ]
will not Occur [ x ] |
| Spill & Disposal Procedures |
| Spill & Leaks : |
| Sweep up. Avoid generating dust. Do not discharge into neutral waters without pretreatment |
| Waste Disposal |
Dispose of in licensed facility. Observe local regulations.
1-5% aqueous solution, Incinerate in an approved facility, observe local regulations. |
| Storage & Handling |
Avoid Eye & Skin contact. Avoid inhaling. Store in a cool, dry and well ventilated location.
Avoid dust generation. Ground and Electrically Bond containers and equipment to prevent electrostatic charges. Protect from moisture. |
| Ecological Data |
| Biodegradability |
Analysis |
Method |
| |
<20% DOC Reduction |
OECD 3028/ISO 9888 |
| May cause long-term adverse effect in an aquatic environment |
Aquatic Toxicity : LCSO : > 4.6 < 10 mg. / 1Time : 96 hrs. Species : Leuciscus
idus.
LCO : 5 mg /1 48 : Leuciscus
idus. |
Inhibition of Bacteria in Effluent : Pseudomonas Putida
17 hrs DIN 38412 part B |
| No effect : N/D |
| mg/1 : 50% inhibition : 380 mg/1 |
| HAZARDS CLASSIFICATION |
| Transportation |
| UN/NA |
|
Class |
P.G |
Shipping Name |
| TOG |
: |
N/A |
| LATA |
: |
N/A |
| IMDG |
: |
N/A |
|
| Special Provision : N/A |
| WHMIS INFORMATION |
Danger
May form explosive dust - air mixture Irritates Eyes, Skin respiratory tract.
Avoid Heat |
| PRECAUTIONS |
Wear respirator if exposed to dusts.
Wear rubber, plastic gloves
Wear chemical Goggles
Wear impermeable apron and boots. |
| FIRST AID |
Eye : Flush with water for 15 minutes ad consult a doctor.
Skin : Rinse with water for 15 minutes and consult a doctor.
Ingestion : If victim is consious, give water, do not induce vomiting. Call a doctor immediately.
Inhalation : Remove to fresh air, assist breathing. Consult a doctor. |
| C = Circa N/D = No Data ; N/A = Not Applicable |
| © Nanz Medscience - Material safety data sheet Povidone Iodine, Specialty chemicals manufacturers India, Specialty chemicals exporters Canada. |